5 industrial sump pump basin

Zoeller - Zoeller 641-0030 Model JX641 Explosion Proof Sewage Pump 3.0 HP 200V 3PH 25' Cord 3" Vertical Discharge #ZLR641-0030

Zoeller Model JX641 Explosion Proof Sewage Pump Description

This series of submersible pumps is designed for use in residential or commercial wastewater applications in Class I, Division 1, Group C and D environments. Each pump is FM/CSA approved and features innovative motor and electrical enclosures that are designed to reduce the risk of vapor ignition both inside and outside the pump. Should vapors inside the electrical enclosures become ignited, the enclosuresare engineered to contain the event and prevent escalation. Each pump is constructed of hardware that will allow it to operate safely and efficiently in extreme conditions. As with every Zoeller pump, each one is 100% factory tested to ensure quality and reliability for years of trouble free performance! This attention to detail is an inherent feature of every pump in this series, making it one of the most reliable in the industry.

Zoeller Model JX641 Explosion Proof Sewage Pump Features and Benefits

cCSAus Rated Class I, Division 1, Groups C & D and Class Zone 1, Groups IIA & IIB Construction

Tested to FM Standards 3600 and 3615 by CSA

Class 30 Cast Iron Construction

All Units are Double Seal for Extra Motor Protection

Corrosion-Resistant, Powder Coated Epoxy Finish

Stainless Steel Screws, Washers, Tags and Seal Assembly

Explosion Proof Motor - 1750 RPM, Hermetically Sealed and Oil-Filled for Added Heat Dissipation

Thermal Sensor

Continuous Duty Operation in Submerged Conditions

Maximum Temperature for Sewage or Dewatering - 104°F (40°C) with 1.2 Service Factor

416 Stainless Steel Motor Shaft

All Models Pass 2-1/2" (63 mm) Spherical Solids

3” NPT Vertical, 3" Horizontal Flanged or 4" Horizontal Flanged Discharge Available

Intrinsically Safe Control Panels Available (Simplex Panel 10-1561 and Duplex Panel 10-10-1589)

Zoeller 641-0030 Explosion Proof Sewage Pump Specifications

VOLTAGE: 3ø, 200V, 60Hz

HORSEPOWER: 3.0 HP

AMP DRAW (full load): 11.0

MOTOR TYPE: 3 Phase

RPM: 1750

MAXIMUM HEAD: 44'

MAXIMUM CAPACITY: 460 GPM

SWITCH TYPE: Manual

DISCHARGE PIPE SIZE: 3" NPT Vertical

MAXIMUM SOLIDS HANDLING: 2-1/2" Spherical Solid

IMPELLER TYPE: Ductile Iron, Non-Clogging Semi-Open

CORD LENGTH: 25' Type UL listed Power and Sensor Cord

BODY CONSTRUCTION: Cast Iron

MAXIMUM OPERATING TEMPERATURE: 104°F (40C)

DUTY RATING: Continuous

HAZARDOUS DUTY: Class I, Division 1, Groups C & D and Class Zone 1, Groups IIA & IIB Construction

Zoeller Limited Warranty

Zoeller products often carry warranty terms that vary in length based on the product type. Refer to the installation manual for specific warranty term.

Manufacturer warrants, to the purchaser and subsequent owner during the warranty period, every new product to be free from defects in material and workmanship under normal use and service, when properly used and maintained, for a period of three years from the date of purchase. Proof of purchase is required. Parts that fail within the warranty period, that inspections determine to be defective in material or workmanship, will be repaired, replaced or remanufactured at Manufacturer's option, provided however, that by so doing we will not be obligated to replace an entire assembly, the entire mechanism or the complete unit. No allowance will be made for shipping charges, damages, labor or other charges that may occur due to product failure, repair or replacement.

This warranty does not apply to and there shall be no warranty for any material or product that has been disassembled without prior approval of Manufacturer, subjected to misuse, misapplication, neglect, alteration, accident or act of nature; that has not been installed, operated or maintained in accordance with Manufacturer's installation instructions; that has been exposed to outside substances including but not limited to the following: sand, gravel, cement, mud, tar, hydrocarbons, hydrocarbon derivatives (oil, gasoline, solvents, etc.), or other abrasive or corrosive substances, wash towels or feminine sanitary products, etc. in all pumping applications. The warranty set out in the paragraph above is in lieu of all other warranties expressed or implied; and we do not authorize any representative or other person to assume for us any other liability in connection with our products.

Contact Manufacturer at, 3649 Cane Run Road, Louisville, Kentucky 40211, Attention: Customer Service Department to obtain any needed repair or replacement of part(s) or additional information pertaining to our warranty.

MANUFACTURER EXPRESSLY DISCLAIMS LIABILITY FOR SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES OR BREACH OF EXPRESSED OR IMPLIED WARRANTY; AND ANY IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE AND OF MERCHANTABILITY SHALL BE LIMITED TO THE DURATION OF THE EXPRESSED WARRANTY.

Some states do not allow limitations on the duration of an implied warranty, so the above limitation may not apply to you. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights which vary from state to state.